FREESTANDING WARNING LINE
The Millenium Freestanding Warning Line is used to delineate areas on roofs to allow work and worker movements in full compliance with provincial regulations* for the prevention of falls from heights.
Attached files
Open or select files to share.
Description
RECOMMENDED USE
- Delineate a work area on a roof with a slope equal to or less than 15° (3/12)
- Control the movement of workers by creating rooftop traffic zones
- Avoid the risk of falling from a height by delimiting the edge of a roof at 2 meters or any other risk of falling from a height.
ADVANTAGES
- Fully modular system according to your needs
- Durable and robust, requires no maintenance
- White, natural aluminum or painted according to our colour range
- Bases take up little room on the roof
- Possible installation in restricted areas
- Non-penetrating system
- Easy set up on all types of fl at and low-sloped roofs.
COMPLEMENTARY SAFETY EQUIPMENT OF THE MILLENIUM PRODUCT LINE
- Roof guardrail systems
- Roof hatch guardrails
- Protection for rooftop access ladders
- Skylight guardrails
- Permanent fall protection anchors
- Restraint anchor system for rooftop safety
- Vertical lifeline systems
- Horizontal lifeline systems.
Physical Properties
ASSEMBLY PARTS
Cast aluminium 535 clamps fittings according to the properties in the table below with threaded holes and stainless steel set screw.
- Single eye cable fitting: start piece with a hole for cable
- Elbow eye cable fitting: 90-degree corner piece with two cable holes
- Double eye cable fitting: Intermediate pole piece with two cable holes.
| Physical Properties | Metric | English |
|---|---|---|
| Density | 2.57 g/cc | 0.0928 lb/in³ |
| Component Elements Properties | Data | |
|---|---|---|
| Aluminum, Al | 91.4 - 93.3 % | |
| Copper, Cu | ‹= 0.10 % | |
| Iron, Fe | ‹= 0.15 % | |
| Magnesium, Mg | 6.6 - 7.5 % | |
| Manganese, Mn | 0.10 - 0.25 % | |
| Other, chaque | ‹= 0.05 % | |
| Other, total | ‹= 0.15 % | |
| Silicone, Si | ‹= 0.20 % | |
| Titanium, Ti | ‹= 0.25 % |
STRUCTURAL AND SIGNALLING PARTS
- Posts and railings : Aluminum tube 6061-T6 of 48mm diameter with plastic caps for the end of the tubes
- Stackable bases : Ballast plate of 41.7 lbs each dimension 16” x 12” made of cast iron according to ASTM A-48 class 30 including a 12 mm (1/2″) thick mat for the protection of the roofing system
- Cable: Galvanized steel cable covered with PVC for a total diameter of 6 mm (1/4″) including the two side karabiners
- Flag: 12″ wide PVC coated polyester mesh fabric.